• Home
  • Download PDF
  • Order CD-ROM
  • Order in Print
CONTAMINATION ANALYSIS  OF AFT TRANSMISSION  OIL
DRAIN  AFT TRANSMISSION  OIL

TM-55-1520-240-23-5 CH-47D Heilcopter Manual
Page Navigation
  487    488    489    490    491  492  493    494    495    496    497  
TM  55-1520-240-23-5 6-137 AFT TRANSMISSION  OIL SYSTEM  ALLOWABLE LEAKAGE 6-137 INITIAL  SETUP Applicable Configurations: All Tools: Flashlight Workstand Materials: None Personnel  Required: Medium  Helicopter Repairer Equipment  Condition: Battery Disconnected  (Task  1-39) Electrical  Power Off Helicopter  On  Level  Surface Right  Baffle  Under  Aft  Transmission  Open  (Task  1-2) Prolonged  oil  leakage  can  damage finish  and  create  a  work  hazard by  making  the  fuselage  slippery.   It can  also  affect other  systems  in  the helicopter.  Therefore,  good  judgment must  be  used  when  determining allowable  leakage. The  maximum  allowable  leakage  rate, static or dynamic,  from  any  oil  seal in  the  transmission  is  20  drops (one cubic  centimeter)  per  hour.   If  this limit  is  exceeded,  the  cause  of  the leakage  shall  be  corrected  by repair or  replacement. NOTE If  engines  have  not  been  operated for  30  minutes  or more,  perform a  5  minute  ground  run  (TM 55-1520-240-10). 1. Check  sight  gage  (1) to  determine  oil  level.  Oil level  shall  be  between  the  FULL  and  ADD OIL lines  after  a  2  hour  flight. FOLLOW-ON MAINTENANCE: Service  aft transmission  (Task  1-54). Close  baffle  under aft  transmission  (Task  2-2). END  OF  TASK 6-501







Western Governors University

Privacy Statement
Press Release
Contact

© Copyright Integrated Publishing, Inc.. All Rights Reserved. Design by Strategico.